What we didn’t notice at first was the car behind, Alan’s rare Brasilia, looking very normal beside Dave’s creation and all the other wild rides nestling in the Bedfordshire countryside. It’s quite a few month’s since Alan finished the rebuild and all has not gone smoothly. The first event was the Lands End, when the Brasilia started to run roughly on the way to Popham. Alan stopped to tinker and the so and so absolutely refused to fire up again. Suspecting fuel starvation Alan squirted some jungle juice directly down its throat(s) and turned the motor over. It duly spat the fuel back out of the carbs and the wiring caught fire. The Brasilia was on the retired list before reaching the start!
Once the wiring was remedied the original problem had to be fixed and it was an interesting one. If the Brasilia was left overnight it would fire up and run OK for a while, then cough and die, defying all attempts to re-start. However, if it was left a while it started quite readily again. But would only run a short while before repeating the whole ghastly sequence. Finally Alan found the problem. Have you guessed? That’s right, there was a piece of paper in the brand spanking new petrol tank. It got sucked over the tank outlet, starving the engine of fuel. However, as the petrol pump stopped sucking the paper would eventually float away, allowing the motor to start again. Boy oh boy!
Anyway, the tank problem was all sorted out in time for the Manx Classic, so it was off on the Steam Packet to the Isle of Man. It started well, but half way through the event the engine started a terrible knock which Alan finally diagnosed as a small end on the way out. He retired and limped home, with Dave Nash in close attendance in case the Brasilia expired on the motorway. Surprisingly things didn’t get any worse, but the noise continued, and Alan prepared to rip the motor apart as soon as he got home. No sooner he taken the silencer off when it clanked and rattled as he put it down. You’ve guessed, the “small end” was a loose baffle. Nearly as bad as when I retired from the Edinburgh with loose wheel-nuts!
This was soon sorted and off went entries for the Testing Trial and The Edinburgh. During the Testing Trial the gearbox started to lock up and Alan discovered that there is terrible play in the diff that needs investigating. Meanwhile the linkage to one of the carbs broke and couldn’t be mended on the spot. Alan set the tick-over up high on the offender and drove home using the other carb!
No time to fix the diff before the Edinburgh. But look out for Alan as he will be driving his familiar Type 3 Fastback. As my friend Rowland Derry used to say when things were not going so well “it’s good here in’it”.
Alan’s new tank came from a VW part’s outlet in Venezuela. This guy can supply practically any Brasilia part except the front wings. The phone bills not to much of a problem, as Alan uses E-Mail to contact him, at the cost of a local call. It’s just as well that Alan found him. Just imagine the reaction of your local VW dealership if you went in “got a tank for a Brasilia squire”.
We have been publishing stuff about Classic Trials on the Web since 1995 and always appreciate feedback. Comments, Corrections, Criticism & Concerns are all welcome. You can leave a comment to have your say here on this web site or our Social Media
Classical Gas 